GM Service Manual Online
For 1990-2009 cars only
Makes 🢒 Chevrolet 🢒 1996 🢒 Chevy MD Bus Chassis (B Model) 🢒 Bulletins 🢒 Warranty Administation - August, 2000 Labor Time Guide Updates

Warranty Administation - August, 2000 Labor Time Guide Updates

Subject:Warranty Administration -- August, 2000 Labor Time Guide Updates

Models:1996-2001 Passenger Cars and Trucks


This bulletin addresses changes to the published General Motors Labor Time Guides. These changes (new or revised) are the result of new time studies and/or dealer "Requests For Review" being handled by the GM Service Operations Group. They are effective upon receipt. All changes will appear in the next printing of the Labor Time Guide.

LTG Update - All Applicable Platforms

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

A/C SYSTEM - LEAK TEST DISCHARGED SYSTEM

  • NOTE: This diagnosis time is to be used when necessary to re-charge the A/C system and locate a leak with an electronic leak detector and/or flourescent dye.

N

 

0.1-0.5

0.1-0.5

0.1-0.5

0.1-0.5

0.1-0.5

0.1-0.5

  • NOTE: This labor operation is for reference only. The actual time to perform the diagnosis should be included in "Regular Labor Hours" for the repair of the labor operation submitted.

 

 

 

 

 

 

 

 

  • NOTE: If leak can not be found, use labor operation D4450.

 

 

 

 

 

 

 

 

A/C SYSTEM - LEAK TEST DYE DIAGNOSIS

  • NOTE: This labor operation is to to be used when necessary to re-charge the A/C system and add flourescent dye. This labor operation was created in the event that a leak could not be found and the customer would bring the vehicle back at a later date.

N

D4450

0.1-0.5

0.1-0.5

0.1-0.5

0.1-0.5

0.1-0.5

0.1-0.5

  • NOTE: Only the system capacity of R134a refrigerant and one bottle flourescent dye can be charged to the warranty repair order.

 

 

 

 

 

 

 

 

*IND: N - New/R - Revised

LTG Update - C Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

0.3

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

SOLENOID, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

  • PART GP: 3.130
  • POLICY: E

 

J6391

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

VALVE, EVAPORATIVE EMISSION CANISTER PURGE VACUUM - REPLACE

 

J6441

--

0.3

0.3

0.3

0.3

0.3

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

N

 

--

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

*IND: N - New/R - Revised

LTG Update - C/K Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

ARM, PITMAN - REPLACE

  • PART GP: 6.859
  • NOTE: For check and adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.
  • THE PREVIOUS "NOTE" NO LONGER APPLIES TO LABOR OPERATION E7900.

R

E7900

 

 

 

 

 

 

C TRUCK

 

 

0.4

0.4

0.4

0.4

0.4

0.4

K TRUCK

 

 

1.2

1.2

1.2

1.2

1.2

 

ADD:

 

 

 

 

 

 

 

 

  • A- W/Hydraulic Brake Booster

 

 

0.1

0.1

0.1

0.1

0.1

0.1

BEARING, CRANKSHAFT MAIN - REPLACE

  • PART GP: 0.096

 

J1150

 

 

 

 

 

 

  • INC: Use of plastic type gauge

 

 

 

 

 

 

 

 

  • NOTE: Applies to V8 Engine, Codes H, K, M, R

 

 

 

 

 

 

 

 

ONE BEARING

 

 

 

 

 

 

 

 

MANUAL TRANS

R

 

 

 

 

 

 

 

C TRUCK

 

 

6.8

6.8

6.8

6.8

6.8

 

K TRUCK

 

 

6.8

6.8

6.8

6.8

6.8

 

AUTO TRANS

R

 

 

 

 

 

 

 

C TRUCK

 

 

6.8

6.8

6.8

6.8

6.8

 

K TRUCK

 

 

6.8

6.8

6.8

6.8

6.8

 

3500 HD

R

 

 

 

 

 

 

 

AUTO TRANS

 

 

4.6

4.6

4.6

4.6

4.6

4.6

MANUAL TRANS

 

 

3.8

3.8

3.8

3.8

3.8

3.8

ADD:

 

 

 

 

 

 

 

 

  • A- W/Engine Oil Cooler

 

 

0.1

0.1

0.1

0.1

0.1

0.1

  • B- W/Skid Plate

 

 

0.2

0.2

0.2

0.2

0.2

 

  • C- To Replace Main Bearings (Each Additional)

R

 

0.2

0.2

0.2

0.2

0.2

0.2

  • D- To Replace All Main Bearings

R

 

0.7

0.7

0.7

0.7

0.7

0.7

  • E- To Replace Connecting Rod Bearings (Each)

R

 

0.2

0.2

0.2

0.2

0.2

0.2

  • F- To Replace All Connecting Rod Bearings

R

 

1.3

1.3

1.3

1.3

1.3

1.3

  • G- To Clean Parts On Vehicles Over 30,000 Miles/48,000 Kilometers if Nec

 

 

0.2

0.2

0.2

0.2

0.2

0.2

CRANKSHAFT - REPLACE

  • NOTE: Applies to V8 Engine, Codes H, K, M, R

 

J1200

 

 

 

 

 

 

  • No Change to "INC" or "PART GP"

 

 

 

 

 

 

 

 

C TRUCK

R

 

7.3

7.3

7.3

7.3

7.3

 

K TRUCK

R

 

7.3

7.3

7.3

7.3

7.3

 

3500 HD

 

 

7.7

7.7

7.7

7.7

7.7

7.7

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C

 

 

0.6

0.6

0.6

0.6

0.6

0.6

  • B- With A.I.R.

R

 

0.1

0.1

0.1

0.1

0.1

0.1

  • C- W/Engine Oil Cooler

 

 

0.3

0.3

0.3

0.3

0.3

0.3

  • D- To R&R Cyl Head

 

 

 

 

 

 

 

 

One

 

 

1.5

1.5

1.5

1.5

1.5

1.5

Both

 

 

1.8

1.8

1.8

1.8

1.8

1.8

  • E- To Replace Piston Rings Only (INC: Ream ridge, check all ring clearances and clean grooves as nec).

 

 

 

 

 

 

 

 

Each Piston

 

 

0.2

0.2

0.2

0.2

0.2

0.2

All Pistons

 

 

1.6

1.6

1.6

1.6

1.6

1.6

F- To Replace Rod Only (INC: Ream ridge).

 

 

 

 

 

 

 

 

Each Rod

 

 

0.5

0.5

0.5

0.5

0.5

0.5

All Rods

 

 

3.7

3.7

3.7

3.7

3.7

3.7

G- To Replace Piston (INC: Ream ridge and R&R rod from piston. Check piston for size and wear. Check bore size, taper, and out of round. Check piston fit and all ring clearances).

 

 

 

 

 

 

 

 

Each Piston

 

 

0.5

0.5

0.5

0.5

0.5

0.5

All Pistons

 

 

3.7

3.7

3.7

3.7

3.7

3.7

H- To Clean Part On Vehicles Over 30,000 Miles/48,000 Kilometers if Nec

 

 

0.3

0.3

0.3

0.3

0.3

0.3

CRANKSHAFT - REPLACE

  • NOTE: Applies to V8 Diesel Engine, Codes F, P, S
  • No Change to "INC", "PART GP" or "POLICIES"

 

J1200

 

 

 

 

 

 

LEFT HAND DRIVE

 

 

12.9

12.9

12.9

12.9

12.9

12.9

RIGHT HAND DRIVE

R

 

--

--

11.7

11.7

11.7

 

  • No Change to "ADD" Conditions

 

 

 

 

 

 

 

 

RADIATOR ASSEMBLY - R&R

  • NOTE: No Change to "PART GP", "POLICY", "INC" or "NOTE"

 

J3080

 

 

 

 

 

 

GAS

R

 

1.2

1.2

1.2

1.2

1.2

1.2

DIESEL

 

 

0.9

0.9

0.9

0.9

0.9

0.9

  • NOTE: No Change to "ADD" Conditions

 

 

 

 

 

 

 

 

*IND: N - New/R - Revised

LTG Update - C/K - New Body Style - Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

SOLENOID, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

  • POLICY: E

 

J6391

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

VALVE, EVAPORATIVE EMISSION CANISTER VENT SOLENOID - REPLACE

N

J6441

--

--

--

0.3

0.3

0.3

ADD:

 

 

 

 

 

 

 

 

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

 

 

--

--

--

0-0.3

0-0.3

0-0.3

*IND: N - New/R - Revised

LTG Update - E Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

COMPRESSOR ASSEMBLY - REPLACE

  • PART GP: 9.170

 

D4440

1.2

1.2

1.2

1.2

1.2

1.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

0.5

0.5

0.5

0.5

0.5

0.5

  • B- To Install Liquid Line Filter (THIS "ADD" CONDITION HAS BEEN DELETED)

R

 

 

 

 

 

 

 

*IND: N - New/R - Revised

LTG Update - E/J Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

NET, REAR COMPONENT CARGO - REPLACE

N

C4610

 

 

 

 

0.2

0.2

VALVE, EVPORATIVE EMISSION CANISTER CONTROL - REPLACE

 

J6324

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

*IND: N - New/R - Revised

LTG Update - F Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

FILTER, IN-LINE - REPLACE

N

D3255

 

 

 

 

 

0.3

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

FILTER, IN-LINE - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

0.3

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

PUMP, ENGINE OIL - REPLACE

  • PART GP: 1.652
  • NOTE: Applies to V8 Engine, Code G and P
  • No Change to "ADD" Condition

 

J1020

 

 

 

 

 

 

  • MANUAL TRANS

R

 

3.8

3.8

5.8

5.8

5.4

5.4

  • AUTO TRANS

 

 

2.2

2.2

4.5

4.5

4.5

4.5

SOLENOID, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

 

J6391

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

VALVE, EVAPORATIVE EMISSION CANISTER PURGE VACUUM - REPLACE

 

J6441

--

0.3

0.3

0.3

0.3

0.3

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

N

 

--

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

*IND: N - New/R - Revised

LTG Update - G Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

0.3

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

*IND: N - New/R - Revised

LTG Update - G Van Platform

OPERATION DESCRIPTIO

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

RESISTOR, BLOWER MOTOR - REPLACE

  • PART GP: 9.275
  • NOTE: No Change to Labor Operations D1000, D1001 or D1005

R

D1002

 

 

 

 

 

 

A/C GAS

 

 

0.2

0.2

0.2

0.2

0.2

0.2

A/C DIESEL

 

 

0.4

0.4

0.4

0.4

0.4

0.4

  • No Change to "ADD" Conditions

 

 

 

 

 

 

 

 

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.4

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System Without C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.5

  • B- Recover/Recharge A/C System With C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.7

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

0.8

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System Without C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.5

  • B- Recover/Recharge A/C System With C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.7

PISTON, ROD AND/OR RINGS - REPLACE

  • PART GP: 0.626
  • No Changes to "INCs"
  • NOTE: No Change to Labor Operations J1300 or J1301

 

 

 

 

 

 

 

 

  • NOTE: Applies to V8 Engine, Code R

 

 

 

 

 

 

 

 

BOTH BANKS

R

J1307

12.4

12.4

12.4

12.4

12.4

12.4

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C

 

 

0.7

 

 

 

 

 

  • B- With Rear A/C

N

 

0.8

0.8

0.8

0.8

0.8

0.8

  • C- W/Cruise Control

 

 

0.3

0.3

0.3

0.3

0.3

0.3

  • D- W/Engine Oil Cooler

N

 

0.1

0.1

0.1

0.1

0.1

0.1

  • E- To Recondition All Valves

 

 

 

 

 

 

 

 

  • One Bank

N

 

1.4

1.4

1.4

1.4

1.4

1.4

  • Both Banks

N

 

2.8

2.8

2.8

2.8

2.8

2.8

  • F- To Replace Rings Only

 

 

 

 

 

 

 

 

  • Each Additional Piston

R

 

0.2

0.2

0.2

0.2

0.2

0.2

  • All Pistons

R

 

1.3

1.3

1.3

1.3

1.3

1.3

  • G- To Replace Rod Only

 

 

 

 

 

 

 

 

  • Each Additional Rod

 

 

0.5

0.5

0.5

0.5

0.5

0.5

  • All Rods

R

 

3.1

3.1

3.1

3.1

3.1

3.1

  • H- To Replace Piston

 

 

 

 

 

 

 

 

  • Each Additional Piston

 

 

0.5

0.5

0.5

0.5

0.5

0.5

  • All Pistons

R

 

2.8

2.8

2.8

2.8

2.8

2.8

  • I- To Clean Parts On Vehicles Over 30,000 Miles/48,000 Kilometers If Nec

 

 

 

 

 

 

 

 

  • Right or Left

 

 

0.3

0.3

0.3

0.3

0.3

0.3

  • Both

 

 

0.4

0.4

0.4

0.4

0.4

0.4

VENT, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

 

J6389

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

SOLENOID, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

 

J6391

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

*IND: N - New/R - Revised

LTG Update - H Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

0.3

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

SOLENOID, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

  • PART GP 3:130
  • POLICY: E

 

J6391

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

*IND: N - New/R - Revised

LTG Update - J Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

PANEL/CARRIER ASSEMBLY, INSTRUMENT CONTROL - REPLACE

  • NOTE: No Change to "PART GP", or "INCs"

 

C2540

 

 

 

 

 

 

CHEVROLET

R

 

1.9

1.9

1.9

1.9

1.9

1.9

PONTIAC

 

 

2.2

2.2

2.2

2.2

2.2

2.2

  • No Change to "ADD" Conditions

 

 

 

 

 

 

 

 

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

0.8

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

SOLENOID, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

 

J6391

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

SOLENOID, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

 

J6441

0.2

0.2

0.3

0.3

0.3

0.3

ADD:

 

 

 

 

 

 

 

 

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

N

 

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

SWITCH ASSEMBLY, AUTO TRANS FLUID PRESSURE - REPLACE

R

K6351

6.3

6.3

6.3

6.3

6.3

6.3

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

 

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SHAFT AND/OR SEAL, MANUAL - REPLACE

 

 

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours.

R

 

 

 

 

 

 

 

SHAFT

 

K6501

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.5

9.5

9.5

9.5

9.5

9.5

ENGINE CODE 4

R

 

--

--

--

8.6

8.6

8.6

SEAL

 

K6529

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.5

9.5

9.5

9.5

9.5

9.5

ENGINE CODE 4

R

 

--

--

--

8.6

8.6

8.6

ADD:

 

 

 

 

 

 

 

 

  • B- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

LEVER, DETENT - REPLACE

 

K6502

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.5

9.5

9.5

9.5

9.5

9.5

ENGINE CODE 4

R

 

--

--

--

8.6

8.6

8.6

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

WIRING HARNESS AND/OR SOLENOID - REPLACE

  • POLICY: E

 

 

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours.

R

 

 

 

 

 

 

 

1 - 2 SHIFT SOLENOID

 

K6555

 

 

 

 

 

 

ENGINE CODES D & T

 

 

6.2

6.2

6.2

6.2

6.2

6.2

ENGINE CODE 4

R

 

--

--

--

6.7

6.7

6.7

2 - 3 SHIFT SOLENOID

 

K6556

 

 

 

 

 

 

ENGINE CODES D & T

 

 

6.2

6.2

6.2

6.2

6.2

6.2

ENGINE CODE 4

R

 

--

--

--

6.7

6.7

6.7

TCC PWM SOLENOID

 

K6557

 

 

 

 

 

 

ENGINE CODES D & T

 

 

6.2

6.2

6.2

6.2

6.2

6.2

ENGINE CODE 4

R

 

--

--

--

6.7

6.7

6.7

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SLEEVE, OUTPUT SHAFT (LEFT) - REPLACE

 

K6942

6.2

6.2

6.2

6.2

6.2

6.2

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

TRANSAXLE ASSEMBLY - REPLACE

  • PART GP: 4.003

 

K7000

 

 

 

 

 

 

  • INC: Cooler line flush, transfer parts, perform Fluid Checking and Functional Test procedures (as outlined in the service manual), and packaging time for Service Replacement Transmission Assembly (SRTA).

R

 

 

 

 

 

 

 

  • NOTE: This operation is for transmission/transaxle replacement only. For transmission/transaxle R&R times use operation J1400.

 

 

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

 

 

 

 

 

 

ENGINE CODE 4

R

 

--

--

--

6.2

6.2

6.2

  • NOTE: Disassemble, inspect and reassemble add time to be used as needed when it has been determined that the cost of overhaul exceeds the cost of replacement.

 

 

 

 

 

 

 

 

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

CONVERTER ASSEMBLY, TRANSAXLE - REPLACE

  • PART GP: 4.115

 

K7020

 

 

 

 

 

 

  • INC: Cooler line flush, oil pressure test, clean and inspect parts and all necessary measurements and adjustments.

R

 

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

7.1

7.1

7.1

7.1

7.1

7.1

ENGINE CODE 4

R

 

--

--

--

6.2

6.2

6.2

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SEAL, TRANSAXLE CONVERTER - REPLACE

  • PART GP: 4.226

 

K7060

 

 

 

 

 

 

  • NOTE: Does not include oil cooler line flush or diagnosis time.

N

 

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

 

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

7.2

7.2

7.2

7.2

7.2

7.2

ENGINE CODE 4

R

 

--

--

--

5.0

5.0

5.0

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

PUMP, TRANSAXLE OIL - R&R OR REPLACE

 

K7121

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.2

8.2

8.2

8.2

8.2

8.2

ENGINE CODE 4

R

 

--

--

--

7.2

7.2

7.2

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

VALVE ASSEMBLY, CONTROL AND GASKET - REPLACE

 

K7123

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.6

8.6

8.6

8.6

8.6

8.6

ENGINE CODE 4

R

 

--

--

--

7.7

7.7

7.7

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SPACER PLATE, CHECK BALL AND GASKET - REPLACE

 

K7128

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.6

8.6

8.6

8.6

8.6

8.6

ENGINE CODE 4

R

 

--

--

--

7.7

7.7

7.7

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SPACER PLATE, CHECK BALL AND GASKET - REPLACE

 

K7221

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.6

9.6

9.6

9.6

9.6

9.6

ENGINE CODE 4

R

 

--

--

--

8.7

8.7

8.7

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SHAFT, TURBINE - REPLACE

 

K7222

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

 

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.9

8.9

8.9

8.9

8.9

8.9

ENGINE CODE 4

R

 

--

--

--

8.0

8.0

8.0

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

O-RING, TURBINE SHAFT- REPLACE

 

K7224

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

6.9

6.9

6.9

6.9

6.9

6.9

ENGINE CODE 4

R

 

--

--

--

6.0

6.0

6.0

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SHAFT, PUMP DRIVE - REPLACE

 

K7226

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.1

8.1

8.1

8.1

8.1

8.1

ENGINE CODE 4

R

 

--

--

--

7.2

7.2

7.2

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SHAFT, OUTPUT - R&R OR REPLACE

 

K7325

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.6

9.6

9.6

9.6

9.6

9.6

ENGINE CODE 4

R

 

--

--

--

8.6

8.6

8.6

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

CHANNEL PLATE AND/OR GASKET - REPLACE

 

 

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

PLATE

 

K7461

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.9

8.9

8.9

8.9

8.9

8.9

ENGINE CODE 4

R

 

--

--

--

8.0

8.0

8.0

GASKET

 

K7462

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.9

8.9

8.9

8.9

8.9

8.9

ENGINE CODE 4

R

 

--

--

--

8.0

8.0

8.0

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

ACCUMULATOR, 1-2; PISTON, SEAL OR SPRING - REPLACE

 

K7465

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.9

8.9

8.9

8.9

8.9

8.9

ENGINE CODE 4

R

 

--

--

--

8.0

8.0

8.0

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

ACCUMULATOR, 2-3; PISTON, SEAL OR SPRING - REPLACE

 

K7466

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.9

8.9

8.9

8.9

8.9

8.9

ENGINE CODE 4

R

 

--

--

--

8.0

8.0

8.0

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

ACCUMULATOR, 3-4; PISTON, SEAL OR SPRING - REPLACE

 

K7467

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.9

8.9

8.9

8.9

8.9

8.9

ENGINE CODE 4

R

 

--

--

--

8.0

8.0

8.0

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SPROCKET, DRIVE - REPLACE

 

K7504

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.9

8.9

8.9

8.9

8.9

8.9

ENGINE CODE 4

R

 

--

--

--

8.0

8.0

8.0

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SPROCKET, DRIVEN - REPLACE

 

K7506

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.8

8.8

8.8

8.8

8.8

8.8

ENGINE CODE 4

R

 

--

--

--

7.9

7.9

7.9

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

LINK ASSEMBLY, TRANSAXLE DRIVE - REPLACE

  • PART GP: 4.131

 

K7520

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

R

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

 

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

8.8

8.8

8.8

8.8

8.8

8.8

ENGINE CODE 4

R

 

--

--

--

7.9

7.9

7.9

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SUPPORT AND SEALS, DRIVE SPROCKET - REPLACE

 

K7522

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.6

9.6

9.6

9.6

9.6

9.6

ENGINE CODE 4

R

 

--

--

--

8.7

8.7

8.7

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SENSOR, INPUT SPEED - REPLACE

 

K7524

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

7.6

7.6

7.6

7.6

7.6

7.6

ENGINE CODE 4

R

 

--

--

--

6.7

6.7

6.7

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

HARNESS ASSEMBLY, CONTROL WIRE - REPLACE

 

K7526

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

7.7

7.7

7.7

7.7

7.7

7.7

ENGINE CODE 4

R

 

--

--

--

6.8

6.8

6.8

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SUPPORT, DRIVEN SPROCKET - REPLACE

 

K7529

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

R

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

 

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.2

9.2

9.2

9.2

9.2

9.2

ENGINE CODE 4

R

 

--

--

--

8.3

8.3

8.3

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

CLUTCH, SECOND - R&R OR REPLACE

 

K7531

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.2

9.2

9.2

9.2

9.2

9.2

ENGINE CODE 4

R

 

--

--

--

8.3

8.3

8.3

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SPRAG ASSEMBLY, INPUT - REPLACE

 

K7537

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.8

9.8

9.8

9.8

9.8

9.8

ENGINE CODE 4

R

 

--

--

--

8.9

8.9

8.9

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

ACTUATOR ASSEMBLY, PARK LOCK - REPLACE

 

 

 

 

 

 

 

 

  • ATTENTION: The following "INC" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • INC: Cooler line flush, oil pressure test, setting T.V. cable, clean and inspect parts and all necessary measurements and adjustments.

R

 

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

  • NOTE: Select the Operation that best describes the primary cause of failure.

 

 

 

 

 

 

 

 

PARKING LOCK ACTUATOR

 

K7541

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.5

9.5

9.5

9.5

9.5

9.5

ENGINE CODE 4

R

 

--

--

--

7.9

7.9

7.9

ADD:

 

 

 

 

 

 

 

 

  • E- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

GUIDE AND SEAL, PARK LOCK ACTUATOR - REPLACE

 

K7549

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

7.1

7.1

7.1

7.1

7.1

7.1

ENGINE CODE 4

R

 

--

--

--

5.0

5.0

5.0

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

CARRIER ASSEMBLY, REACTION - REPLACE

 

K7565

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.2

9.2

9.2

9.2

9.2

9.2

ENGINE CODE 4

R

 

--

--

--

8.3

8.3

8.3

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

CLUTCH ASSEMBLY, REVERSE INPUT - R&R OR REPLACE

 

K7571

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.4

9.4

9.4

9.4

9.4

9.4

ENGINE CODE 4

R

 

--

--

--

8.5

8.5

8.5

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

BAND, INTERMEDIATE/4TH - REPLACE

 

K7573

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.0

9.0

9.0

9.0

9.0

9.0

ENGINE CODE 4

 

 

--

--

--

8.1

8.1

8.1

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

SUPPORT, FORWARD CLUTCH - REPLACE

 

K7577

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.5

9.5

9.5

9.5

9.5

9.5

ENGINE CODE 4

 

 

--

--

--

8.6

8.6

8.6

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

CLUTCH ASSEMBLY, DIRECT AND COAST - R&R OR REPLACE

 

K7581

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.8

9.8

9.8

9.8

9.8

9.8

ENGINE CODE 4

 

 

--

--

--

8.9

8.9

8.9

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

HOUSING, DIRECT & COAST CLUTCH & INPUT SHAFT - REPLACE

 

K7582

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.8

9.8

9.8

9.8

9.8

9.8

ENGINE CODE 4

 

 

--

--

--

8.9

8.9

8.9

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

GEAR, INPUT INTERNAL AND FORWARD CLUTCH HUB - REPLACE

 

K7583

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.2

9.2

9.2

9.2

9.2

9.2

ENGINE CODE 4

 

 

--

--

--

8.3

8.3

8.3

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

CLUTCH, LO ROLLER - REPLACE

 

K7584

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.4

9.4

9.4

9.4

9.4

9.4

ENGINE CODE 4

 

 

--

--

--

8.6

8.6

8.6

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

CARRIER, INPUT - REPLACE

 

K7590

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.1

9.1

9.1

9.1

9.1

9.1

ENGINE CODE 4

 

 

--

--

--

8.3

8.3

8.3

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

GEAR, REACTION INTERNAL - REPLACE

 

K7594

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.1

9.1

9.1

9.1

9.1

9.1

ENGINE CODE 4

 

 

--

--

--

8.3

8.3

8.3

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

BAND, LO/REVERSE - REPLACE

 

K7596

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.2

9.2

9.2

9.2

9.2

9.2

ENGINE CODE 4

 

 

--

--

--

8.3

8.3

8.3

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

DIFFERENTIAL AND FINAL DRIVE ASSEMBLY, TRANSAXLE - REPLACE

 

K7620

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.5

9.5

9.5

9.5

9.5

9.5

ENGINE CODE 4

 

 

--

--

--

8.6

8.6

8.6

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

DIFFERENTIAL AND FINAL DRIVE ASSEMBLY, TRANSMISSION - R&R

 

K7629

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.5

9.5

9.5

9.5

9.5

9.5

ENGINE CODE 4

 

 

--

--

--

8.6

8.6

8.6

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

DIFFERENTIAL AND FINAL DRIVE ASSEMBLY, TRANSMISSION - R&R

 

K7629

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.5

9.5

9.5

9.5

9.5

9.5

ENGINE CODE 4

 

 

--

--

--

8.6

8.6

8.6

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

GEAR, FINAL DRIVE INTERNAL - R&R OR REPLACE

 

K7750

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

9.5

9.5

9.5

9.5

9.5

9.5

ENGINE CODE 4

 

 

--

--

--

8.6

8.6

8.6

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

CASE, TRANSAXLE - REPLACE

  • PART GP: 4.103

 

K7800

 

 

 

 

 

 

  • ATTENTION: The following "NOTE" has been deleted from this labor operation.

 

 

 

 

 

 

 

 

  • "NOTE" For check & adjust toe-in, refer to operation E2000 and add the applicable times to the regular hours column.

R

 

 

 

 

 

 

 

ENGINE CODES D & T

 

 

10.1

10.1

10.1

10.1

10.1

10.1

ENGINE CODE 4

R

 

--

--

--

9.3

9.3

9.3

ADD:

 

 

 

 

 

 

 

 

  • A- With A/C (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • NOTE: No Change to Remaining "ADD" Conditions.

 

 

 

 

 

 

 

 

*IND: N - New/R - Revised

LTG Update - K Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

COMPRESSOR ASSEMBLY - REPLACE

  • PART GP: 9.170

 

D4440

1.2

1.2

1.2

1.2

1.2

1.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

0.5

0.5

0.5

0.5

0.5

0.5

  • B- To Install Liquid Line Filter (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

*IND: N - New/R - Revised

LTG Update - Ksp Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

BEARING AND HUB ASSEMBLY, FRONT WHEEL - REPLACE

  • PART GP: 6.307

 

 

 

 

 

 

 

 

  • INC: R&R Caliper with Bracket, Rotor and Dust Shield

R

E2320

 

 

 

 

 

 

RIGHT

 

 

0.9

0.9

0.9

0.9

0.9

0.9

LEFT

 

E2321

0.9

0.9

0.9

0.9

0.9

0.9

BOTH

 

E2327

1.5

1.5

1.7

1.7

1.7

1.7

SENSOR, CRANKSHAFT POSITION - REPLACE

  • No Change to "ADD" Condition

R

J4355

0.4

0.4

0.3

0.3

0.9

0.9

SWITCH, EVAPORATIVE EMISSION CANISTER PURGE THERMAL VACUUM - REPLACE

 

J6335

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

VALVE, EVAPORATIVE EMISSION CANISTER PURGE VACUUM - REPLACE

 

J6441

--

--

0.2

0.2

0.2

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

N

 

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

*IND: N - New/R - Revised

LTG Update - M Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

VALVE, EVAPORATOR EMISSION CANISTER CONTROL - REPLACE

 

J6324

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

SOLENOID, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

 

J6391

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

VALVE, EVAPORATIVE EMISSION CANISTER VENT SOLENOID - REPLACE

R

J6441

--

--

1.6

1.6

1.6

1.6

ADD:

 

 

 

 

 

 

 

 

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

 

 

--

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

*IND: N - New/R - Revised

LTG Update - M/L Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System Without C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.5

  • B- Recover/Recharge A/C System With C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.7

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

 

Without C69, Rear Auxiliary A/C

--

--

--

--

--

0.5

With C69, Rear Auxiliary A/C

--

--

--

--

--

0.6

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System Without C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.5

  • B- Recover/Recharge A/C System With C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.7

TOE, FRONT - ADJUST

  • NOTE: No Change to existing "NOTES"

R

E2000

 

 

 

 

 

 

M-VAN

 

 

0.8

0.8

0.8

0.8

0.8

0.8

L-VAN

 

 

0.9

0.9

0.9

0.9

0.9

0.9

ROD, STEERING RELAY - REPLACE

  • PART GP: 6.870

 

E7980

0.5

0.5

0.5

0.5

0.5

0.5

  • NOTE: For check and adjust toe-in, refer to operation E2000 and add the applicable time to the regular hours column.

N

 

 

 

 

 

 

 

ADD:

R

 

 

 

 

 

 

 

  • A- To Adjust Toe-In
  • (THIS "ADD" CONDITION HAS BEEN DELETED)

 

 

 

 

 

 

 

 

TIE ROD, INNER - REPLACE

  • PART GP: 6.230

 

 

 

 

 

 

 

 

  • NOTE: For check and adjust toe-in, refer to operation E2000 and add the applicable time to the regular hours column.

N

 

 

 

 

 

 

 

RIGHT

 

E8040

0.3

0.3

0.3

0.3

0.3

0.3

LEFT

 

E8041

0.3

0.3

0.3

0.3

0.3

0.3

BOTH

 

E8047

0.4

0.4

0.4

0.4

0.4

0.4

ADD:

R

 

 

 

 

 

 

 

  • A- To Adjust Toe-In
  • (THIS "ADD" CONDITION HAS BEEN DELETED)

 

 

 

 

 

 

 

 

TIE ROD END AND/OR ADJUSTER SLEEVE - REPLACE

  • PART GP: 6.233

 

 

 

 

 

 

 

 

  • NOTE: For check and adjust toe-in, refer to operation E2000 and add the applicable time to the regular hours column.

N

 

 

 

 

 

 

 

RIGHT

 

E8060

0.4

0.4

0.4

0.4

0.4

0.4

LEFT

 

E8061

0.4

0.4

0.4

0.4

0.4

0.4

BOTH

 

E8067

0.7

0.7

0.7

0.7

0.7

0.7

ADD:

R

 

 

 

 

 

 

 

  • A- To Adjust Toe-In
  • (THIS "ADD" CONDITION HAS BEEN DELETED)

 

 

 

 

 

 

 

 

PLUG, TRANSFER CASE DRAIN - REPLACE

R

K4290

0.3

0.3

0.3

0.3

0.3

0.3

PLUG, TRANSFER CASE FILL - REPLACE

N

K4291

0.2

0.2

0.2

0.2

0.2

0.2

*IND: N - New/R - Revised

LTG Update - N Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

LOCK, COMPARTMENT (INSTRUMENT PANEL) - REPLACE

  • PART GP: 10.266

 

C2100

 

 

 

 

 

 

MALIBU & CUTLASS

 

 

--

0.2

0.2

0.2

0.2

0.2

GRAND AM & ALERO

R

 

0.2

0.2

0.2

0.6

0.6

0.6

ACHIEVA & SKYLARK

 

 

0.2

0.2

0.2

 

 

 

  • No Change to "ADD" Condition

 

 

 

 

 

 

 

 

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.5

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

0.5

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

CORE, EVAPORATOR - REPLACE

 

D3320

 

 

 

 

 

 

MALIBU & CUTLASS

R

 

--

4.9

4.9

4.9

4.9

4.9

GRAND AM & ALERO

 

 

2.1

2.1

2.1

1.3

1.3

1.3

ACHIEVA - 4 CYL

 

 

2.1

2.1

2.1

 

 

 

ACHIEVA - 6 CYL

 

 

2.1

2.1

2.1

 

 

 

SKYLARK - 4 CYL

 

 

2.1

2.1

2.1

 

 

 

SKYLARK - 6 CYL

 

 

2.1

2.1

2.1

 

 

 

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

R

 

0.5

0.5

0.5

0.5

0.5

0.5

INSULATOR AND/OR SUPPORT, REAR STABILIZER SHAFT - REPLACE

  • PART GP: 7.243
  • NOTE: No Change to Labor Operations E4180 or E4181

 

 

 

 

 

 

 

 

BOTH

 

E4187

 

 

 

 

 

 

MALIBU & CUTLASS

R

 

--

0.5

0.5

0.5

0.5

0.5

GRAND AM & ALERO

 

 

--

--

--

0.3

0.3

0.3

GEAR ASSEMBLY, POWER STEERING - R&R

 

E9720

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

GEAR ASSEMBLY, POWER STEERING - REPLACE

  • PART GP: 6.508
  • INC: Transfer outer tie rods.
  • NOTE: For check and adjust toe-in, refer to Operation E2000 and add the applicable times to the regular hours column.

N

E9740

 

 

 

 

 

 

ACHIEVA & SKYLARK

 

 

1.2

1.2

1.2

1.2

 

 

GRAND AM & ALERO

 

 

1.2

1.2

1.2

1.7

1.7

.17

MALIBU & CUTLASS

 

 

--

1.7

1.7

1.7

1.7

1.7

CYLINDER, BRAKE MASTER - REPLACE

  • PART GP: 4.650

 

H0640

 

 

 

 

 

 

MALIBU & CUTLASS

 

 

--

0.6

0.6

0.6

0.6

0.6

ACHIEVA & SKYLARK

 

 

1.2

1.2

1.2

 

 

 

GRAND AM & ALERO

R

 

1.2

1.2

1.2

1.0

1.0

1.0

MOTOR PACK (ABS) - REPLACE

R

H2506

0.6

2.0

2.0

2.0

2.0

2.0

  • No Change to "ADD" Condition

 

 

 

 

 

 

 

 

BOOT, PARKING BRAKE HANDLE - REPLACE

N

H2815

--

--

--

0.8

0.8

0.8

WIRES, SPARK PLUG - REPLACE

  • No Change to "PART GP", or "POLICY"

 

 

 

 

 

 

 

 

ONE

 

J4206

 

 

 

 

 

 

EXC ENGINE CODE M, E and J

 

 

0.2

0.2

0.2

 

 

 

ENGINE CODE M, E and J

 

 

0.2

0.2

0.2

0.3

0.3

0.3

  • No Change to "ADD" Conditions

 

 

 

 

 

 

 

 

SENSOR, CAMSHAFT POSITION - REPLACE

  • POLICY: E

 

J4350

 

 

 

 

 

 

4 CYL

 

 

0.2

0.2

0.2

0.2

0.2

0.2

6 CYL

R

 

0.8

0.9

0.9

0.9

0.9

0.9

ADD:

 

 

 

 

 

 

 

 

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

 

 

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

SOLENOID, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

 

J6391

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

VALVE, EVAPORATIVE EMISSION CANISTER VENT SOLENOID - REPLACE

R

J6441

0.2

0.2

0.2

0.3

0.3

0.3

ADD:

 

 

 

 

 

 

 

 

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

N

 

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

*IND: N - New/R - Revised

       

LTG Update - S/T Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

ARM, STEERING IDLER - REPLACE

  • PART GP: 6.895
  • NOTE: For alignment times refer to operation E2000 and add applicable times to the regular hours column.

R

E7960

 

 

 

 

 

 

S TRUCK

 

 

0.4

0.4

0.4

0.4

0.4

0.4

T TRUCK

 

 

0.4

0.4

0.4

0.4

0.4

0.4

ADD:

R

 

 

 

 

 

 

 

  • A- W/Skid Plate

 

 

--

--

0.2

0.2

0.2

0.2

  • B- To Adjust Toe-In
  • (THIS "ADD" CONDITION HAS BEEN DELETED).

 

 

 

 

 

 

 

 

ROD, STEERING RELAY - REPLACE

  • PART GP: 6.870
  • NOTE: For alignment times refer to operation E2000 and add applicable times to the regular hours column.

R

E7980

0.6

0.6

0.6

0.6

0.6

0.6

ADD:

R

 

 

 

 

 

 

 

  • A- To Adjust Toe-In
  • (THIS "ADD" CONDITION HAS BEEN DELETED).

 

 

 

 

 

 

 

 

TIE ROD END AND/OR ADJUSTER SLEEVE - REPLACE

  • PART GP: 6.230
  • NOTE: For alignment times refer to operation E2000 and add applicable times to the regular hours column.

R

 

 

 

 

 

 

 

RIGHT

 

E8040

0.4

0.4

0.4

0.4

0.4

0.4

LEFT

 

E8041

0.4

0.4

0.4

0.4

0.4

0.4

BOTH

 

E8047

0.5

0.5

0.5

0.5

0.5

0.5

TIE ROD END AND/OR ADJUSTER SLEEVE - REPLACE

  • PART GP: 6.233
  • NOTE: For alignment times refer to operation E2000 and add applicable times to the regular hours column.

R

 

 

 

 

 

 

 

RIGHT

 

E8060

0.4

0.4

0.4

0.4

0.4

0.4

LEFT

 

E8061

0.4

0.4

0.4

0.4

0.4

0.4

BOTH

 

E8067

0.7

0.7

0.7

0.7

0.7

0.7

*IND: N - New/R - Revised

       

LTG Update - U/X Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.3

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System Without C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.5

  • B- Recover/Recharge A/C System With C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.7

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

0.4

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System Without C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.5

  • B- Recover/Recharge A/C System With C69, Rear Auxiliary A/C

 

 

 

 

 

 

 

0.7

SUPPORT AND SEALS, DRIVE SPROCKET - REPLACE

  • NOTE: Applies to Auto Trans 4T65E

N

K7522

--

--

--

9.8

9.8

9.8

ADD:

 

 

 

 

 

 

 

 

  • A- To Recondition 3-4 Accumulator

 

 

--

--

--

0.2

0.2

0.2

  • B- To Clean and Recondition Valve Body

 

 

--

--

--

1.0

1.0

1.0

  • C- To Recondition Oil Pump

 

 

--

--

--

0.4

0.4

0.4

  • D- To Recondition Trans Completely (Exc Carrier/Diff Final Drive)

 

 

--

--

--

4.2

4.2

4.2

  • E- To Recondition Carrier/Differential Final Drive Assembly

 

 

--

--

--

0.8

0.8

0.8

  • F- To Clean Parts On Vehicle Over 30,000 Miles/48,000 Kilometers If Nec

 

 

--

--

--

0.5

0.5

0.5

*IND: N - New/R - Revised

LTG Update - W Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

MODULE, BLOWER MOTOR CONTROL - REPLACE

R

D0890

--

0.4

0.4

0.4

0.4

0.4

ADD:

 

 

 

 

 

 

 

 

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

 

 

--

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.5

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

 

CHEVROLET, PONTIAC, BUICK

 

 

 

 

 

 

 

0.8

OLDSMOBILE

 

 

 

 

 

 

 

2.2

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

COMPRESSOR ASSEMBLY - REPLACE

  • PART GP: 9.170

 

D4440

 

 

 

 

 

 

ENGINE CODE H

 

 

--

--

--

2.1

2.1

2.1

ENGINE CODE K AND 1

 

 

0.8

0.7

0.7

0.7

0.7

0.7

ENGINE CODE X

 

 

1.1

1.1

 

 

 

 

ENGINE CODE M, T, J AND E

 

 

0.8

0.8

0.8

0.8

0.8

0.8

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

0.5

0.5

0.5

0.5

0.5

0.5

  • B- To Install Liquid Line Filter (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • C- To Install Liquid Line With Filter (THIS "ADD" CONDITION HAS BEEN DELETED).

R

 

 

 

 

 

 

 

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

 

 

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

GEAR ASSEMBLY, POWER STEERING - REPLACE

  • PART GP: 6.508
  • NOTE: For check and adjust toe-in, refer to Operation E2000 and add the applicable times to the regular hours column.

N

E9740

 

 

 

 

 

 

ENGINE CODE M, T, J, E, K, 1, H

 

 

2.0

1.4

1.4

1.4

1.4

1.4

ENGINE CODE X

 

 

2.6

2.6

 

 

 

 

SOLENOID, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

 

J6391

THIS LABOR OPERATION HAS BBEN DELETED FROM ALL APPLICABLE YEARS

VALVE, EVAPORATIVE EMISSION CANISTER VENT SOLENOID - REPLACE

 

J6441

--

0.2

0.2

0.2

0.2

0.2

ADD:

 

 

 

 

 

 

 

 

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

N

 

--

0-0.3

0-0.3

0-0.3

0-0.3

0-0.3

*IND: N - New/R - Revised

LTG Update - Y Platform

OPERATION DESCRIPTION

IND*

OP NUM

MODEL YEAR

96

97

98

99

00

01

YEAR VIN CODE

T

V

W

X

Y

1

FILTER, IN-LINE A/C - REPLACE

N

D3255

 

 

 

 

 

0.4

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

FILTER, IN-LINE A/C - INSTALL

  • NOTE: This Labor Operation can only be used with a Compressor Replacement D4440.

N

D3258

 

 

 

 

 

2.1

ADD:

 

 

 

 

 

 

 

 

  • A- Recover/Recharge A/C System

 

 

 

 

 

 

 

0.5

PULLEY, CRANKSHAFT BALANCER - REPLACE

  • NOTE: Applies to V8 Engine, Codes G, P and 5
  • No Change to "NOTE" or "ADD" Condition

R

J0710

1.3

2.1

2.1

2.3

2.3

2.3

SOLENOID, EVAPORATIVE EMISSION CANISTER VENT CONTROL - REPLACE

 

J6391

THIS LABOR OPERATION HAS BEEN DELETED FROM ALL APPLICABLE YEARS

VALVE, EVAPORATIVE EMISSION CANISTER VENT SOLENOID - REPLACE

N

J6441

0.4

 

 

 

 

 

ADD:

 

 

 

 

 

 

 

 

  • A- Diagnosis Time: You may claim 0.0 to 0.3 hours depending on actual time performing diagnosis.

 

 

0-0.3

 

 

 

 

 

*IND: N - New/R - Revised